Frank W. Burcham

Bio: Frank W. Burcham is an academic researcher from Analytical Services. The author has contributed to research in topics: Fly-by-wire & Flight management system. The author has an hindex of 4, co-authored 4 publications receiving 126 citations.

Engine damage to a nasa dc-8-72 airplane from a high-altitude encounter with a diffuse volcanic ash cloud

Abstract: The National Aeronautics and Space Administration (NASA) DC-8 airborne sciences research airplane inadvertently flew through a diffuse volcanic ash cloud of the Mt. Hekla volcano in February 2000 during a flight from Edwards Air Force Base (Edwards, California) to Kiruna, Sweden. Although the ash plume was not visible to the flight crew, sensitive research experiments and instruments detected it. In-flight performance checks and postflight visual inspections revealed no damage to the airplane or engine first-stage fan blades; subsequent detailed examination of the engines revealed clogged turbine cooling air passages. The engines were removed and overhauled. This paper presents volcanic ash plume analysis, trajectory from satellites, analysis of ash particles collected in cabin air heat exchanger filters and removed from the engines, and data from onboard instruments and engine conditions.

Manual Manipulation of Engine Throttles for Emergency Flight Control

Abstract: If normal aircraft flight controls are lost, emergency flight control may be attempted using only engines thrust. Collective thrust is used to control flightpath, and differential thrust is used to control bank angle. Flight test and simulation results on many airplanes have shown that pilot manipulation of throttles is usually adequate to maintain up-and-away flight, but is most often not capable of providing safe landings. There are techniques that will improve control and increase the chances of a survivable landing. This paper reviews the principles of throttles-only control (TOC), a history of accidents or incidents in which some or all flight controls were lost, manual TOC results for a wide range of airplanes from simulation and flight, and suggested techniques for flying with throttles only and making a survivable landing.

Flight Testing a Propulsion-Controlled Aircraft Emergency Flight Control System on an F-15 Airplane

Abstract: Flight tests of a propulsion-controlled aircraft (PCA) system on an F-15 airplane have been conducted at the NASA Dryden Flight Research Center. The airplane was flown with all flight control surfaces locked both in the manual throttles-only mode and in an augmented system mode. In the latter mode, pilot thumbwheel commands and aircraft feedback parameters were used to position the throttles. Flight evaluation results showed that the PCA system can be used to land an airplane that has suffered a major flight control system failure safely. The PCA system was used to recover the F-15 airplane from a severe upset condition, descend, and land. Pilots from NASA, U.S. Air Force, U.S. Navy, and McDonnell Douglas Aerospace evaluated the PCA system and were favorably impressed with its capability. Manual throttles-only approaches were unsuccessful. This paper describes the PCA system operation and testing. It also presents flight test results and pilot comments.

Even minor volcanic ash encounters can cause major damage to aircraft.

Abstract: SUBTITLE: A RESEARCH AIRCRAFT'S CHANCE ENCOUNTER WITH THE DIFFUSE FRINGES OF AN ASH CLOUD HAS REVEALED THAT SIGNIFICANT DAMAGE CAN OCCUR TO ENGINES WITHOUT THE CREW'S AWARENESS. THE INCIDENT POINTS TO A NEED FOR IMPROVED CLOUD MODELLING AND DEVELOPMENT OF A COST-EFFECTIVE SENSOR FOR DETECTING AIRBORNE PARTICULATES.

Airborne observations of the Eyjafjalla volcano ash cloud over Europe during air space closure in April and May 2010

Abstract: . Airborne lidar and in-situ measurements of aerosols and trace gases were performed in volcanic ash plumes over Europe between Southern Germany and Iceland with the Falcon aircraft during the eruption period of the Eyjafjalla volcano between 19 April and 18 May 2010. Flight planning and measurement analyses were supported by a refined Meteosat ash product and trajectory model analysis. The volcanic ash plume was observed with lidar directly over the volcano and up to a distance of 2700 km downwind, and up to 120 h plume ages. Aged ash layers were between a few 100 m to 3 km deep, occurred between 1 and 7 km altitude, and were typically 100 to 300 km wide. Particles collected by impactors had diameters up to 20 μm diameter, with size and age dependent composition. Ash mass concentrations were derived from optical particle spectrometers for a particle density of 2.6 g cm−3 and various values of the refractive index (RI, real part: 1.59; 3 values for the imaginary part: 0, 0.004 and 0.008). The mass concentrations, effective diameters and related optical properties were compared with ground-based lidar observations. Theoretical considerations of particle sedimentation constrain the particle diameters to those obtained for the lower RI values. The ash mass concentration results have an uncertainty of a factor of two. The maximum ash mass concentration encountered during the 17 flights with 34 ash plume penetrations was below 1 mg m−3. The Falcon flew in ash clouds up to about 0.8 mg m−3 for a few minutes and in an ash cloud with approximately 0.2 mg m−3 mean-concentration for about one hour without engine damage. The ash plumes were rather dry and correlated with considerable CO and SO2 increases and O3 decreases. To first order, ash concentration and SO2 mixing ratio in the plumes decreased by a factor of two within less than a day. In fresh plumes, the SO2 and CO concentration increases were correlated with the ash mass concentration. The ash plumes were often visible slantwise as faint dark layers, even for concentrations below 0.1 mg m−3. The large abundance of volatile Aitken mode particles suggests previous nucleation of sulfuric acid droplets. The effective diameters range between 0.2 and 3 μm with considerable surface and volume contributions from the Aitken and coarse mode aerosol, respectively. The distal ash mass flux on 2 May was of the order of 500 (240–1600) kg s−1. The volcano induced about 10 (2.5–50) Tg of distal ash mass and about 3 (0.6–23) Tg of SO2 during the whole eruption period. The results of the Falcon flights were used to support the responsible agencies in their decisions concerning air traffic in the presence of volcanic ash.

A Review of Distributed Electric Propulsion Concepts for Air Vehicle Technology

Abstract: The emergence of distributed electric propulsion (DEP) concepts for aircraft systems has enabled new capabilities in the overall efficiency, capabilities, and robustness of future air vehicles Distributed electric propulsion systems feature the novel approach of utilizing electrically-driven propulsors which are only connected electrically to energy sources or power-generating devices As a result, propulsors can be placed, sized, and operated with greater flexibility to leverage the synergistic benefits of aero-propulsive coupling and provide improved performance over more traditional designs A number of conventional aircraft concepts that utilize distributed electric propulsion have been developed, along with various short and vertical takeoff and landing platforms Careful integration of electrically-driven propulsors for boundary-layer ingestion can allow for improved propulsive efficiency and wake-filling benefits The placement and configuration of propulsors can also be used to mitigate the trailing vortex system of a lifting surface or leverage increases in dynamic pressure across blown surfaces for increased lift performance Additionally, the thrust stream of distributed electric propulsors can be utilized to enable new capabilities in vehicle control, including reducing requirements for traditional control surfaces and increasing tolerance of the vehicle control system to engine-out or propulsor-out scenarios If one or more turboelectric generators and multiple electric fans are used, the increased effective bypass ratio of the whole propulsion system can also enable lower community noise during takeoff and landing segments of flight and higher propulsive efficiency at all conditions Furthermore, the small propulsors of a DEP system can be installed to leverage an acoustic shielding effect by the airframe, which can further reduce noise signatures The rapid growth in flight-weight electrical systems and power architectures has provided new enabling technologies for future DEP concepts, which provide flexible operational capabilities far beyond those of current systems While a number of integration challenges exist, DEP is a disruptive concept that can lead to unprecedented improvements in future aircraft designs

Tracking volcanic sulfur dioxide clouds for aviation hazard mitigation

Abstract: Satellite measurements of volcanic sulfur dioxide (SO2) emissions can provide critical information for aviation hazard mitigation, particularly when ash detection techniques fail. Recent developments in space-based SO2 monitoring are discussed, focusing on daily, global ultraviolet (UV) measurements by the Ozone Monitoring Instrument (OMI) on NASA’s Aura satellite. OMI’s high sensitivity to SO2 permits long-range tracking of volcanic clouds in the upper troposphere and lower stratosphere (UTLS) and accurate mapping of their perimeters to facilitate avoidance. Examples from 2006 to 2007 include eruptions of Soufriere Hills (Montserrat), Rabaul (Papua New Guinea), Nyamuragira (DR Congo), and Jebel at Tair (Yemen). A tendency for some volcanic clouds to occupy the jet stream suggests an increased threat to aircraft that exploit this phenomenon. Synergy between NASA A-Train sensors such as OMI and the Atmospheric Infrared Sounder (AIRS) on the Aqua satellite can provide critical information on volcanic cloud altitude. OMI and AIRS SO2 data products are being produced in near real-time for distribution to Volcanic Ash Advisory Centers (VAACs) via a NOAA website. Operational issues arising from these improved SO2 measurements include the reliability of SO2 as proxy for co-erupted ash, the duration of VAAC advisories for long-lived volcanic clouds, and the potential effects of elevated concentrations of SO2 and sulfate aerosol in ash-poor clouds on aircraft and avionics (including cumulative effects after multiple inadvertent transits through dilute clouds). Further research is required in these areas. Aviation community assistance is sought through continued reporting of sulfurous odors or other indications of diffuse volcanic cloud encounters, in order to validate the satellite retrievals.