Utilization of sewage sludge in EU application of old and new methods—A review
TL;DR: In this article, the authors review past and future trends in sludge handling, focusing mainly at thermal processes (e.g. pyrolysis, wet oxidation, gasification) and the utilization of sewage sludge in cement manufacture as a co-fuel.
Abstract: The European Union has made progress in dealing with municipal wastewater in individual countries and as a corporate entity. However, it intends to make still further and substantial progress over the next 15 years. Currently, the most widely available options in the EU are the agriculture utilization, the waste disposal sites, the land reclamation and restoration, the incineration and other novel uses. The selection of an option on a local basis reflects local or national, cultural, historical, geographical, legal, political and economic circumstances. The degree of flexibility varies from country to country. In any case sludge treatment and disposal should always be considered as an integral part of treatment of wastewater. There is a wide range of other uses for sludge, which exploit its energy or chemical content, namely the thermal processes. The present paper sought to review past and future trends in sludge handling, focusing mainly at thermal processes (e.g. pyrolysis, wet oxidation, gasification) and the utilization of sewage sludge in cement manufacture as a co-fuel.
Citations
More filters
TL;DR: In this paper, the authors evaluated the effect of different sewage sludge compost treatments, applied as basal dressing, on the productivity of the energy crop Cynara cardunculus L. (cynara).
34 citations
TL;DR: In this paper , various conversion technologies for transformation of wet wastes to bioenergy and biochar, including anaerobic digestion, gasification, incineration, hydrothermal carbonization, slow and fast pyrolysis, are comprehensively reviewed.
34 citations
TL;DR: In this article, two steel sludges with similar ternary component (silicon oxide, alumina, and flux) compositions, but considerably different particle size distribution, were individually added in clay and sintered, leading to a conclusion that particle size distributions play a critical role in both glassy surface formation and pellet bloating during sintering.
34 citations
TL;DR: The thermal conversion of sewage sludge to biochar offers a promising alternative use for a hazardous waste material with potential benefits to agricultural productivity and soil quality as mentioned in this paper, but the results of the experiments were limited.
Abstract: The thermal conversion of sewage sludge to biochar offers a promising alternative use for a hazardous waste material with potential benefits to agricultural productivity and soil quality. Three short-term greenhouse experiments were conducted to evaluate the effect of corn cob (CC) and sewage sludge (SS) biochars, with their anaerobically treated counterparts, on soil properties and plant growth in an infertile Oxisol. The anaerobically treated SS biochar showed the greatest concentration of bioavailable essential nutrients, but treatment only resulted in increased yields for the SS biochar in the first crop in the absence of added fertilizer. Both CC and SS biochars in combination with fertilizer doubled plant growth compared to the control in the first crop cycle, produced no significant effect in the second cycle, and more than tripled plant growth for the SS biochars in the third cycle. High ash content with high nutrient contributions (especially P) and a persistent liming effect explain the benefits of the SS biochars to plant growth. The SS biochar showed promise in mitigating the negative effects of soil Mn toxicity. Sewage sludge biochars reduced Cd bioavailability and had no significant effect on the bioavailability of other potentially toxic metals compared to the control.
34 citations
Cites background from "Utilization of sewage sludge in EU ..."
...Traditional methods of disposal (land application, incineration, and landfilling) pose significant threats to environmental quality and human health [1]....
[...]
...Managing sewage sludge is one of the most challenging and urgent problems facing an increasingly urban global population [1]....
[...]
TL;DR: The use of sewage sludge as feed for the pyrolysis process to produce bio-oil reduces its cost and makes its production economically competitive with fossil diesel as mentioned in this paper, however, the cost of raw materials is 80% of the total cost of biooil production.
34 citations
References
More filters
TL;DR: In this paper, an analytical procedure involving sequential chemicai extractions was developed for the partitioning of particulate trace metals (Cd, Co, Cu, Ni, Pb, Zn, Fe, and Mn) into five fractions: exchangeable, bound to carbonates, binding to Fe-Mn oxides and bound to organic matter.
Abstract: An analytical procedure involving sequential chemicai extractions has been developed for the partitioning of particulate trace metals (Cd, Co, Cu, Ni, Pb, Zn, Fe, and Mn) into five fractions: exchangeable, bound to carbonates, bound to Fe-Mn oxides, bound to organic matter, and residual. Experimental results obtained on replicate samples of fluvial bottom sediments demonstrate that the relative standard deviation of the sequential extraction procedure Is generally better than =10%. The accuracy, evaluated by comparing total trace metal concentrations with the sum of the five Individual fractions, proved to be satisfactory. Complementary measurements were performed on the Individual leachates, and on the residual sediments following each extraction, to evaluate the selectivity of the various reagents toward specific geochemical phases. An application of the proposed method to river sediments is described, and the resulting trace metal speciation is discussed.
10,518 citations
"Utilization of sewage sludge in EU ..." refers background in this paper
...Over the last decades, a great variety of extraction schemes, both simple and sequential have been developed and, although some methods have been widely used [12,13] none has been unreservedly accepted by the scientific community....
[...]
Book•
01 Jan 1972
TL;DR: Wastewater Engineering: An Overview of Wastewater Engineering, Methods and Implementation Considerations as mentioned in this paper is a good starting point for a discussion of the issues of wastewater engineering. But, it is not a complete survey of the entire literature.
Abstract: Wastewater Engineering: An Overview. Wastewater Flowrates. Wastewater Characteristics. Wastewater Treatment Objective, Methods, and Implementation Considerations. Introduction to Wastewater Treatment Plant Design. Physical Unit Operations. Chemical Unit Processes. Biological Unit Processes. Design of Facilities for Physical and Chemical Treatment of Wastewater. Design of Facilities for the Biological Treatment of Wastewater. Advanced Wastewater Treatment. Design of Facilities for the Treatment and Disposal of Sludge. Natural-Treatment Systems. Small Wastewater Treatment Systems. Management of Wastewater from Combined Sewers. Wastewater Reclamation and Reuse.
3,826 citations
TL;DR: In this article, a review of the current and future issues related to the combustion of sewage sludge is presented, and a number of technologies for thermal processing of sludge are discussed in three groups, i.e., mono-combustion, cocombustions and alternative processes.
1,026 citations
"Utilization of sewage sludge in EU ..." refers background in this paper
...Multiple hearth and fluidized bed furnaces are the most popular and the latter is becoming widely applied [24]....
[...]
...Analysis has shown that about 78–98% of Cd, Cr, Cu, Ni, Pb and Zn present in the sewage sludge are retained in the ash, whereas up to 98% of the Hg may be released into the atmosphere with the flue gas [24]....
[...]
...The whole process is occurring in two distinctive regimes [24]:...
[...]
TL;DR: In this article, the authors proposed a standardization with respect to grain size effects, commonly achieved by analyzing the sieve fraction <63μm, which is used to pin point major sources of metal pollution and to estimate the toxicity potential of dredged materials.
Abstract: Sediment analyses are used to pin‐point major sources of metal pollution and to estimate the toxicity potential of dredged materials on agricultural land. For source assessments (Part I of the present review) standardization is needed with respect to grain size effects, commonly achieved by analyzing the sieve fraction <63μm. Further aspects include sampling methods, evaluation of background data and extent of anthropogenic metal enrichment.
530 citations