Soybean oil

About: Soybean oil is a research topic. Over the lifetime, 11154 publications have been published within this topic receiving 234952 citations. The topic is also known as: soya oil & soy bean oil.

Enzyme-Assisted Aqueous Extraction of Oil and Protein from Soybeans and Cream De-emulsification

Abstract: The effects of two commercial endoproteases (Protex 6L and Protex 7L, Genencor Division of Danisco, Rochester, NY, USA) on the oil and protein extraction yields from extruded soybean flakes during enzyme-assisted aqueous extraction processing (EAEP) were evaluated. Oil and protein were distributed in three fractions generated by the EAEP: cream + free oil, skim and insolubles. Protex 6L was more effective for extracting free oil, protein and total solids than Protex 7L. Oil and protein extraction yields of 96 and 85%, respectively, were obtained using 0.5% Protex 6L. Enzymatic and pH treatments were evaluated to de-emulsify the oil-rich cream. Cream de-emulsification generated three fractions: free oil, an intermediate residual cream layer and an oil-lean second skim. Total cream de-emulsification was obtained when using 2.5% Protex 6L and pH 4.5. The extrusion treatment was particularly important for reducing trypsin inhibitor activity (TIA) in the protein-rich skim fraction. TIA reductions of 69 and 45% were obtained for EAEP skim (the predominant protein fraction) from extruded flakes and ground flakes, respectively. Protex 6L gave higher degrees of protein hydrolysis (most of the polypeptides being between 1,000 and 10,000 Da) than Protex 7L. Raffinose was not detected in the skim, while stachyose was eliminated by α-galactosidase treatment.

Use of palm oil for frying in comparison with other high-stability oils

Abstract: Today, palm oil and its products, mainly palm olein, belong to the most important oils used for the preparation of fried food. The reason is that the oil is relatively cheap, it is available in huge amounts, it has a high oxidative stability and results in high-quality and tasty foods. Thus, the oil meets the demands of the consumer and the producer of fried food. The suitability of palm oil and its products for frying was widely demonstrated in many investigations, and the paper shows some examples for the comparison of palm oil with other commonly used oils. Nevertheless palm oil and its products have a decisive drawback in comparison to conventional vegetable oils like rapeseed or soybean oil, resulting from the high content of saturated fatty acids, which are unfavourable in view of health aspects. Therefore, the search for healthier oils is going on and, in the meantime, several genetically or conventionally modified vegetable oils have appeared on the market. The paper demonstrates that palm oil and its products have a similar frying performance compared to the new so-called “high-oleic” oils.

Effect of dietary palm oils on mammary carcinogenesis in female rats induced by 7,12-dimethylbenz(a)anthracene.

Abstract: Female Sprague-Dawley rats, 50 days of age, were treated with a single dose of 5 mg of 7,12-dimethylbenz(a)anthracene intragastrically. 3 days after carcinogen treatment, the rats were put on semisynthetic diets containing 20% by weight of corn oil (CO), soybean oil (SBO), crude palm oil (CPO), refined, bleached, deodorized palm oil (RBD PO) and metabisulfite-treated palm oil (MCPO) for 5 months. During the course of experiments, rats fed on different dietary fats had similar rate of growth. Rats fed 20% CO or SBO diet have higher tumor incidence than rats fed on palm oil (PO) diets; however differences of mean tumor latency periods among the groups were not statistically significant. At autopsy, rats fed on high CO or SBO diets had significantly more tumors than rats fed on the three PO diets. Our results showed that high PO diets did not promote chemically induced mammary tumorigenesis in female rats when compared to high CO or SBO diets. CO and SBO differ greatly from the palm oils in their contents of tocopherols, tocotrienols, and carotenes. But further experiments would be required to determine whether the observed differences in tumor incidence and tumor numbers were due to the differences in these minor components or due to the unique triglyceride structure of the palm oils. Analysis of the fatty acid profiles of plasma total lipids of tumor-bearing rats and of the tumor total lipids showed that, with the exception of arachidonic acid, the fatty acid profiles reflect the nature of the dietary fats. At autopsy, there were no differences in the plasma total cholesterol contents among rats fed on different dietary fats, but rats fed on palm oil diets had a significantly higher plasma triglyceride level than that of rats fed CO or SBO diets. As for the tumor lipids, there were no significant differences in the triglyceride, diglyceride, and phospholipid levels when the CO or SBO groups were compared to the palm oil groups.