Soybean oil

About: Soybean oil is a research topic. Over the lifetime, 11154 publications have been published within this topic receiving 234952 citations. The topic is also known as: soya oil & soy bean oil.

Dry extrusion as an aid to mechanical expelling of oil from soybeans

Abstract: A new concept is described for mechanical extraction of oil from soybeans, using dry extrusion as a pretreatment. It was found that coarsely ground whole soybeans at 10 to 14% moisture could be extrusion cooked so that the extrudate emerges from the die in a semi-fluid state. The dwell time within the extruder was less than 30 seconds, and the temperature was raised to about 135 C. The semi-fluid extrudate was immediately pressed in a continuous screw press to obtain high quality oil and press cake. Extrusion prior to expelling greatly increased the throughput of the expeller over the rated capacity. An oil recovery of 70% was obtained in single pass expelling using pilot model expellers. Higher recovery rates can be expected with commercial scale expellers. The high temperature-short time extrusion cooking process eliminates the prolonged heating and holding of raw material in conventional expelling. Under the experimental conditions, press cake with 50% protein, 6% residual oil and 90% inactivation of trypsin inhibitors was obtained. The low fat cake was easily ground in a hammer mill without the usual problems associated with milling of whole beans. The expelled oil was remarkably stable with an AOM stability of 15 hr, which is comparable to refined deodorized oil according to NSPA specifications. The new procedure offers potential for producing natural soybean oil and food grade low fat soy flour by a relatively low cost operation. It may be adopted as an improvement to existing conventional expelling operations in less developed countries or as a commercial or on-farm operation for producing value added products from soybeans within the U.S.

Assessment of olive oil adulteration by reversed‐phase high‐performance liquid chromatography/amperometric detection of tocopherols and tocotrienols

Abstract: A method involving reversed-phase high-performance liquid chromatography with amperometric detection has been developed for the analysis of tocopherols and tocotrienols in vegetable oils. The sample preparation avoids saponification. Recoveries of α-tocotrienol and γ-tocotrienol in extra virgin olive oil were 97.0 and 102.0%, respectively. No tocotrienols were detected in olive, hazelnut, sunflower, and soybean oils, whether virgin or refined. However, relatively high levels of tocotrienols were found in palm and grapeseed oils. This method could detect small quantities (1–2%) of palm and grapeseed oils in olive oil or in any tocotrienol-free vegetable oil and might, therefore, help assess authenticity of vegetable oils.

Oxidation and quality of soybean oil: a preliminary study of the anisidine test

Abstract: The anisidine test, a measure of secondary oxidation products in glyceride oils, was applied to a number of soybean salad oils processed from sound and damaged soybeans. A highly significant correlation (−0.68) was found between the anisidine values of salad oils from sound soybeans and their flavor scores. Multiple correlations between flavor scores, anisidine, and peroxide values yielded a correlation of 0.81 and provided a method for predicting the initial flavor scores of sound soybean salad oils. Similar data for oils from damaged beans gave a highly significant, but lower, correlation (−0.65). Comparative studies indicated that sound crude oils usually contain lower levels of oxidation products than damaged crude. Oxidation in both sound and damaged crudes increased roughly in proportion to iron content. Reproducibility of the test and the effects of hydrogenation, accelerated storage, and fluorescent light on anisidine values were studied. Analysis of damaged oils before and after deodorization showed that little, if any, reduction of anisidine value occurred. Deodorization of sound oils, however, lowered anisidine values. In comparison with damaged oils, the anisidine values of sound oils were lower at comparable stages of processing. The poor quality of damaged soybean oil was substantiated by organoleptic evaluations. Flavor scores of oils given special processing treatments increased as anisidine values decreased.

Enzymatic interesterification of tallow-sunflower oil mixtures

Abstract: In an effort to improve the physical and/or thermal characteristics of solid fats, the enzymatic interesterification of tallow and butterfat with high-oleic sunflower oil and soybean oil was investigated. The two simultaneously occurring reactions, interesterification and hydrolysis, were followed by high-performance liquid chromatography of altered glycerides and by gas-liquid chromatography of liberated free fatty acids. The enzymes used in these studies were immobilized lipases that included either a 1,3-acyl-selective lipase or acis-9-C18-selective lipase. The degree of hydrolysis of the fat/oil mixtures was dependent upon the initial water content of the reaction medium. The extent of the interesterification reaction was dependent on the amount of enzyme employed but not on the reaction temperature over the range of 50–70°C. Changes in melting characteristics of the interesterified glyceride mixtures were followed by differential scanning calorimetry of the residual mixed glycerides after removal of free fatty acids. Interesterification of the glyceride mixes with the two types of enzymes allowed for either a decrease or increase in the solid fat content of the initial glyceride mix.