The present study sheds light on the long-standing challenges associated with high-voltage operation of LiNi(x)Mn(x)Co(1-2x)O2 cathode materials for lithium-ion batteries. Using correlated ensemble-averaged high-throughput X-ray absorption spectroscopy and spatially resolved electron microscopy and spectroscopy, here we report structural reconstruction (formation of a surface reduced layer, to transition) and chemical evolution (formation of a surface reaction layer) at the surface of LiNi(x)Mn(x)Co(1-2x)O2 particles. These are primarily responsible for the prevailing capacity fading and impedance buildup under high-voltage cycling conditions, as well as the first-cycle coulombic inefficiency. It was found that the surface reconstruction exhibits a strong anisotropic characteristic, which predominantly occurs along lithium diffusion channels. Furthermore, the surface reaction layer is composed of lithium fluoride embedded in a complex organic matrix. This work sets a refined example for the study of surface reconstruction and chemical evolution in battery materials using combined diagnostic tools at complementary length scales.

/pdf/surface-reconstruction-and-chemical-evolution-of-jw2m1e1xay.pdf

Surface reconstruction and chemical evolution of stoichiometric layered cathode materials for lithium-ion batteries

An important step in assessing the toxicology of particles is to determine their fate after inhalation. Of particular interest to us are airborne ultrafine particles (UFPs; < 100 nm), which are abundant in ambient urban air and are of the same size as engineered nanoparticles. Translocation to extrapulmonary sites after respiratory tract deposition represents an important mechanism for these particles to cause direct effects in secondary target organs (Oberdorster et al. 2005). The extent to which this process occurs depends on several factors including particle solubility, particle or aggregate size, the site of deposition, and the integrity of the epithelial lining. UFPs deposit efficiently in all regions of the respiratory tract, depending on their size; specifically, as particle size decreases toward the smallest UFPs, nasopharyngeal deposition increases (International Committee on Radiological Protection 1994).

Studies in rats have shown translocation of soluble manganese compounds from the nose along olfactory neuronal pathways to the olfactory bulb (Dorman et al. 2004; Henriksson and Tjalve 2000; Tjalve et al. 1996; Tjalve and Henriksson 1999) after inhalation or intranasal instillation exposures. Likewise, the few studies that have examined the fate of UFPs deposited on the nasal mucosa identified translocation along the neuronal olfactory route as a pathway to the olfactory bulb of the central nervous system (CNS). These include early studies in non-human primates, which demonstrated the translocation of solid nanosized particles (30 nm poliovirus; 50 nm silver-coated gold colloids) along the axons of olfactory nerves into the olfactory bulb (Bodian and Howe 1941a, 1941b; DeLorenzo 1970). We have also shown that inhaled elemental carbon particles (13C; 35 nm, count median diameter) accumulate in rat olfactory bulb after whole-body inhalation (Oberdorster et al. 2004). Regarding penetration into deeper brain regions, Tjalve et al. (1995) demonstrated that soluble ionic Mn instilled into the olfactory chamber of pike has the ability to pass synaptic junctions and migrate from the olfactory tract to more distal regions, including the hypothalamus. Dorman et al. (2004) found Mn in the striatum and cerebellum of rats after subchronic inhalation exposure to a soluble Mn salt (sulfate); however, this was attributed to uptake from the blood. Thus, contributions to brain Mn levels from the blood need to be considered and may also be an issue for inhaled solid UFPs.

The effects of translocated particles in the brain are also important to determine. For example, preliminary information has emerged from populations of welders that some of them may develop parkinsonism 17 years earlier than the general population (Racette et al. 2001). Welding produces high amounts of fumes containing Mn UFPs (Zimmer et al. 2002). Several recent epidemiologic studies describe occupational exposure ranges of approximately 0.01–5 mg/m3 Mn in fumes from various welding processes and materials (Korczynski 2000; Li et al. 2004; Sinczuk-Walczak et al. 2001). Conflicting data emerge from animal studies, however, regarding effects of inhaled Mn compounds in the brain. Henriksson and Tjalve (2000) reported changes in glial fibrillary acidic protein (GFAP) and S-100b, markers of astrocyte activation, in several brain regions from rats exposed intranasally to Mn chloride. However, Dorman et al. (2004) did not find any evidence of changes in GFAP levels in the brain after exposure to Mn sulfate or phosphate. Potential contributing factors to the lack of concurrence in results include differences in the solubilities of the Mn salts used, the doses, and the contribution of olfactory epithelial damage.

In the present study, we sought to address the hypothesis that a major translocation route for inhaled poorly soluble Mn oxide UFPs from deposits in the nose is to the olfactory bulb in the CNS. We characterized the size, oxidation state, and in vitro solubility of gas-phase–generated Mn oxide particles and also compared the translocation kinetics to the olfactory bulb of Mn oxide and MnCl2 that were applied to the nasal epithelium of rats via instillation. We then measured the accumulation of Mn in lung, liver, and olfactory bulb after repeated inhalation exposures with both nares patent or with one naris occluded. We show that Mn oxide UFPs are translocated to and retained in the olfactory bulb (ipsilateral to the patent naris only) and present evidence of exposure-induced effects in that region of the brain. These studies demonstrate the importance of UFPs size and of solubility in olfactory translocation processes.

/pdf/translocation-of-inhaled-ultrafine-manganese-oxide-particles-2xkmxoyp9p.pdf

Translocation of inhaled ultrafine manganese oxide particles to the central nervous system.

In the present study, an in-depth investigation on the structural transformation in a mesoporous γ-MnO2 cathode during electrochemical reaction in a zinc-ion battery (ZIB) has been undertaken. A combination of in situ Synchrotron XANES and XRD studies reveal that the tunnel-type parent γ-MnO2 undergoes a structural transformation to spinel-type Mn(III) phase (ZnMn2O4) and two new intermediary Mn(II) phases, namely, tunnel-type γ-ZnxMnO2 and layered-type L-ZnyMnO2, and that these phases with multioxidation states coexist after complete electrochemical Zn-insertion. On successive Zn-deinsertion/extraction, a majority of these phases with multioxidation states is observed to revert back to the parent γ-MnO2 phase. The mesoporous γ-MnO2 cathode, prepared by a simple ambient temperature strategy followed by low-temperature annealing at 200 °C, delivers an initial discharge capacity of 285 mAh g–1 at 0.05 mA cm–2 with a defined plateau at around 1.25 V vs Zn/Zn2+. Ex situ HR-TEM studies of the discharged electr...

Electrochemically Induced Structural Transformation in a γ-MnO2 Cathode of a High Capacity Zinc-Ion Battery System

In situ X-ray absorption spectroscopy (XAS) is a powerful technique that can be applied to electrochemical systems, with the ability to elucidate the chemical nature of electrocatalysts under reaction conditions. In this study, we perform in situ XAS measurements on a bifunctional manganese oxide (MnOx) catalyst with high electrochemical activity for the oxygen reduction reaction (ORR) and the oxygen evolution reaction (OER). Using X-ray absorption near edge structure (XANES) and extended X-ray absorption fine structure (EXAFS), we find that exposure to an ORR-relevant potential of 0.7 V vs RHE produces a disordered Mn3II,III,IIIO4 phase with negligible contributions from other phases. After the potential is increased to a highly anodic value of 1.8 V vs RHE, relevant to the OER, we observe an oxidation of approximately 80% of the catalytic thin film to form a mixed MnIII,IV oxide, while the remaining 20% of the film consists of a less oxidized phase, likely corresponding to unchanged Mn3II,III,IIIO4. XAS...

In situ X-ray absorption spectroscopy investigation of a bifunctional manganese oxide catalyst with high activity for electrochemical water oxidation and oxygen reduction.

http://ematweb.cmi.ua.ac.be/emat/pdf/1786.pdf

Oxidation state and chemical shift investigation in transition metal oxides by EELS

We present near edge X-ray absorption spectra of manganese oxides at the Mn L2,3, Mn K, and O K edges to investigate the relative sensitivity of the edges to bonding and structure. Collectively, the spectra probe local electronic structure and intermediate range crystal structure. Spin independent full multiple scattering calculations of the Mn K edge give good agreement with data above threshold and qualitatively reproduce the prepeak that is observed for each compound. We show that the apparent prepeak for MnO is not due to p-d hybridization at the Mn atom (in accordance with symmetry principles) or quadrupolar transitions but originates from multiple scattering within the fifth shell. We present spin dependent multiple scattering calculations of the O K edge and show that this edge allows for a more direct description of the 3d states than either the Mn L edge or K edge prepeak, which are complicated by multiplet effects.

/pdf/multiple-scattering-calculations-of-bonding-and-x-ray-543jkvtdm5.pdf

P. G. Conrad

Papers

Multiple Scattering Calculations of Bonding and X-ray Absorption Spectroscopy of Manganese Oxides