Gallium oxide (Ga2O3) is emerging as a viable candidate for certain classes of power electronics, solar blind UV photodetectors, solar cells, and sensors with capabilities beyond existing technologies due to its large bandgap. It is usually reported that there are five different polymorphs of Ga2O3, namely, the monoclinic (β-Ga2O3), rhombohedral (α), defective spinel (γ), cubic (δ), or orthorhombic (e) structures. Of these, the β-polymorph is the stable form under normal conditions and has been the most widely studied and utilized. Since melt growth techniques can be used to grow bulk crystals of β-GaO3, the cost of producing larger area, uniform substrates is potentially lower compared to the vapor growth techniques used to manufacture bulk crystals of GaN and SiC. The performance of technologically important high voltage rectifiers and enhancement-mode Metal-Oxide Field Effect Transistors benefit from the larger critical electric field of β-Ga2O3 relative to either SiC or GaN. However, the absence of clear demonstrations of p-type doping in Ga2O3, which may be a fundamental issue resulting from the band structure, makes it very difficult to simultaneously achieve low turn-on voltages and ultra-high breakdown. The purpose of this review is to summarize recent advances in the growth, processing, and device performance of the most widely studied polymorph, β-Ga2O3. The role of defects and impurities on the transport and optical properties of bulk, epitaxial, and nanostructures material, the difficulty in p-type doping, and the development of processing techniques like etching, contact formation, dielectrics for gate formation, and passivation are discussed. Areas where continued development is needed to fully exploit the properties of Ga2O3 are identified.

A review of Ga2O3 materials, processing, and devices

J. Y. Tsao,* S. Chowdhury, M. A. Hollis,* D. Jena, N. M. Johnson, K. A. Jones, R. J. Kaplar,* S. Rajan, C. G. Van de Walle, E. Bellotti, C. L. Chua, R. Collazo, M. E. Coltrin, J. A. Cooper, K. R. Evans, S. Graham, T. A. Grotjohn, E. R. Heller, M. Higashiwaki, M. S. Islam, P. W. Juodawlkis, M. A. Khan, A. D. Koehler, J. H. Leach, U. K. Mishra, R. J. Nemanich, R. C. N. Pilawa-Podgurski, J. B. Shealy, Z. Sitar, M. J. Tadjer, A. F. Witulski, M. Wraback, and J. A. Simmons

/pdf/ultrawide-bandgap-semiconductors-research-opportunities-and-49ev1zu2ym.pdf

Ultrawide-Bandgap Semiconductors: Research Opportunities and Challenges

This is a review article on the current status and future prospects of the research and development on gallium oxide (Ga2O3) power devices. Ga2O3 possesses excellent material properties, in particular for power device applications. It is also attractive from an industrial viewpoint since large-size, high-quality wafers can be manufactured from a single-crystal bulk synthesized by melt–growth methods. These two features have drawn much attention to Ga2O3 as a new wide bandgap semiconductor following SiC and GaN. In this review, we describe the recent progress in the research and development on fundamental technologies of Ga2O3 devices, covering single-crystal bulk and wafer production, homoepitaxial thin film growth by molecular beam epitaxy and halide vapor phase epitaxy, as well as device processing and characterization of metal–semiconductor field-effect transistors, metal–oxide–semiconductor field-effect transistors and Schottky barrier diodes.

https://iopscience.iop.org/article/10.1088/0268-1242/31/3/034001/pdf

Recent progress in Ga2O3 power devices

β-Ga2O3 bulk crystals were grown by the edge-defined film-fed growth (EFG) process and the floating zone process. Semiconductor substrates containing no twin boundaries with sizes up to 4 in. in diameter were fabricated. It was found that Si was the main residual impurity in the EFG-grown crystals and that the effective donor concentration (N d − N a) of unintentionally doped crystals was governed by the Si concentration. Intentional n-type doping was shown to be possible. An etch pit observation revealed that the dislocation density was on the order of 103 cm−3. N d − N a for the samples annealed in nitrogen ambient was almost the same as the Si concentration, while for the samples annealed in oxygen ambient, it was around 1 × 1017 cm−3 and independent of the Si concentration.

http://iopscience.iop.org/article/10.7567/JJAP.55.1202A2/pdf

High-quality β-Ga2O3 single crystals grown by edge-defined film-fed growth

Single-crystal gallium oxide (Ga2O3) metal-oxide-semiconductor field-effect transistors were fabricated on a semi-insulating β-Ga2O3 (010) substrate. A Sn-doped n-Ga2O3 channel layer was grown by molecular-beam epitaxy. Si-ion implantation doping was performed to source and drain electrode regions for obtaining low-resistance ohmic contacts. An Al2O3 gate dielectric film formed by atomic layer deposition passivated the device surface and significantly reduced gate leakage. The device with a gate length of 2 μm showed effective gate modulation of the drain current with an extremely low off-state drain leakage of less than a few pA/mm, leading to a high drain current on/off ratio of over ten orders of magnitude. A three-terminal off-state breakdown voltage of 370 V was achieved. Stable transistor operation was sustained at temperatures up to 250 °C.

Depletion-mode Ga2O3 metal-oxide-semiconductor field-effect transistors on β-Ga2O3 (010) substrates and temperature dependence of their device characteristics

We report a demonstration of single-crystal gallium oxide (Ga2O3) metal-semiconductor field-effect transistors (MESFETs). A Sn-doped Ga2O3 layer was grown on a semi-insulating β-Ga2O3 (010) substrate by molecular-beam epitaxy. We fabricated a circular MESFET with a gate length of 4 μm and a source–drain spacing of 20 μm. The device showed an ideal transistor action represented by the drain current modulation due to the gate voltage (VGS) swing. A complete drain current pinch-off characteristic was also obtained for VGS < −20 V, and the three-terminal off-state breakdown voltage was over 250 V. A low drain leakage current of 3 μA at the off-state led to a high on/off drain current ratio of about 10 000. These device characteristics obtained at the early stage indicate the great potential of Ga2O3-based electrical devices for future power device applications.

Gallium oxide (Ga2O3) metal-semiconductor field-effect transistors on single-crystal β-Ga2O3 (010) substrates

N-type Ga2O3 homoepitaxial thick films were grown on β-Ga2O3(010) substrates by ozone molecular beam epitaxy. The epitaxial growth rate was increased by more than ten times by changing from the (100) plane to the (010) plane. The carrier concentration of the epitaxial layers could be varied within the range of 1016–1019 cm-3 by changing the Sn doping concentration. Platinum Schottky barrier diodes (SBDs) on 1.4-µm-thick β-Ga2O3 homoepitaxial layers were demonstrated for the first time. The SBDs exhibited a reverse breakdown voltage of 100 V, an on-resistance of 2 mΩ cm2, and a forward voltage of 1.7 V (at 200 A/cm2).

https://iopscience.iop.org/article/10.1143/APEX.5.035502/pdf

Device-Quality β-Ga2O3 Epitaxial Films Fabricated by Ozone Molecular Beam Epitaxy

Gallium oxide (Ga2O3) is a strong contender for power electronic devices. The material possesses excellent properties such as a large bandgap of 4.7–4.9 eV for a high breakdown field of 8 MV cm−1. Low cost, high volume production of large single-crystal β-Ga2O3 substrates can be realized by melt-growth methods commonly adopted in the industry. High-quality n-type Ga2O3 epitaxial thin films with controllable carrier densities were obtained by ozone molecular beam epitaxy (MBE). We fabricated Ga2O3 metal-semiconductor field-effect transistors (MESFETs) and Schottky barrier diodes (SBDs) from single-crystal Ga2O3 substrates and MBE-grown epitaxial wafers. The MESFETs delivered excellent device performance including an off-state breakdown voltage (Vbr) of over 250 V, a low leakage current of only few μA mm−1, and a high drain current on/off ratio of about four orders of magnitude. The SBDs also showed good characteristics such as near-unity ideality factors and high reverse Vbr. These results indicate that Ga2O3 can potentially meet or even exceed the performance of Si and typical widegap semiconductors such as SiC or GaN for ultrahigh-voltage power switching applications.

Kohei Sasaki

Papers

Gallium oxide (Ga2O3) metal-semiconductor field-effect transistors on single-crystal β-Ga2O3 (010) substrates

Recent progress in Ga2O3 power devices

Depletion-mode Ga2O3 metal-oxide-semiconductor field-effect transistors on β-Ga2O3 (010) substrates and temperature dependence of their device characteristics

Device-Quality β-Ga2O3 Epitaxial Films Fabricated by Ozone Molecular Beam Epitaxy

Development of gallium oxide power devices